Pages: [1] 2
Author Topic: In search of Bosch datasheets or crossreferences to standard numbers  (Read 50496 times)
thenextdon13
Newbie
*

Karma: +4/-1
Offline Offline

Posts: 20



In search of Bosch datasheets or crossreferences to standard numbers

Hello folks-

I have started trying to trace the circuits to cpu ports for the ME7.5 ECU in my 2001 AWM 1.8t A4 ecu.  (picture attached)

One of the hardest things has been trying to track down which bosch part is what, and find circuit diagrams/pinouts for the components.

This means it must be nearly impossible to figure out which datasheet is for which component i the box, especially if there are multiple components with the same package but different part numbers.

In search of datasheets for the following Bosch parts.. (or equivalent parts).. or suggestions as how to figure out what they actually are:
Bosch 30397 (all coil modules go here, most likely a coil driver 20 pin dip, perhaps the ck110 http://www.semiconductors.bosch.de/pdf/CK110_Product_Info.pdf)
Bosch 30348 (found info on this, it is supposed to be same as the motorola mc33186, and it drives the drive by wire motor)
Bosch 30381 Controls at least variable cam solenoid and idle air control valve
Bosch 30344 Controls at least the fuel injectors and n75 wastegate bypass valve
Bosch 30380 controls at least baro sensor and leak detection pump-- but has a TON of pins???
Bosch 30343 have not yet found any interaction
Bosch 30345  (appears to be wideband controller, as nearly all wideband leads go there perhaps the cj110?  www.semiconductors.bosch.de/pdf/CJ110_Product_Info.pdf

Hmm interesting point, the cj110 appears to connect with only one pin to the CPU.. via and a/d converter.. which could open for a small circuit to run perhaps a gauge?  Smiley hmmm

Anyway, any suggestions are welcome..

thanks
Camden



Logged
thenextdon13
Newbie
*

Karma: +4/-1
Offline Offline

Posts: 20


« Reply #1 on: October 17, 2009, 11:34:13 PM »

Hmm don't see the attachment, and don't see an 'edit post' link... so lets try this again.

Also, here is the pinout i came up with based on the schematics...
http://spreadsheets.google.com/ccc?key=0Atc5QQQNw_5ndHV3aGNua1NXdnh5N3lEQlUyS0J4V0E&hl=en
Logged
Tony@NefMoto
Administrator
Hero Member
*****

Karma: +131/-4
Offline Offline

Posts: 1389


2001.5 Audi S4 Stage 3


« Reply #2 on: October 19, 2009, 11:44:43 AM »

Awesome work.

This may help: http://www.kwp2000.info/bosch_ic

PS: I did all of this myself a few years back, so I can post up the circuit board traces for the B5 S4 ecu if you are interested. Shocked
Logged

Remember you have to log in if you want to see the file attachments!
Info or questions, please add to the wiki: http://www.nefariousmotorsports.com/wiki
Follow NefMoto developments on Twitter: http://twitter.com/nefmoto
thenextdon13
Newbie
*

Karma: +4/-1
Offline Offline

Posts: 20


« Reply #3 on: October 19, 2009, 12:59:14 PM »

Thanks for the link!

Unfortunately all of the p/n's i have start with 303 and there are none of them listed at that site Sad

Sure, post what you can-- there may be some similarites Smiley... but don't take too much time away from other more useful things if it takes any time to do.

take care
Camden
Logged
thenextdon13
Newbie
*

Karma: +4/-1
Offline Offline

Posts: 20


« Reply #4 on: October 21, 2009, 10:45:00 PM »

Well, i've had some luck but had to go about it the hard way...
Found that Bosch saves all of their datasheets for download in the same directory(http://www.semiconductors.bosch.de/pdf).  They disallow directory listing (standard), but Google crawls all of the links on their pages, so a search of simply "site:http://www.semiconductors.bosch.de/pdf" returns all linked pdf's

Going through them and looking at the package options, then verifying outuput/vcc/ground pins I have come up with the following:
Bosch 30397 = Bosch CK110 = 6 channel 'Interface for Ignition Drivers (www.semiconductors.bosch.de/pdf/CK110_Product_Info.pdf)
Bosch 30348 = Bosch CJ220 = 6A H-Bridge (Drive By Wire motor controller) (www.semiconductors.bosch.de/pdf/CJ220_Product_Info.pdf)
Bosch 30381 = Bosch CJ420B = Smart Quad Switch - runs cam adjust, idle, etc (www.semiconductors.bosch.de/pdf/CJ406_CJ420B_Product_Info.pdf)
Bosch 30344 = Bosch CJ920* = Motronic IC - runs injectors, n075 and other valves (www.semiconductors.bosch.de/pdf/CJ920_Product_Info.pdf)
Bosch 30345 = Bosch CJ110 = LSU4 control and amplifier circuit (www.semiconductors.bosch.de/pdf/CJ110_Product_Info.pdf)

(google spreadsheet has been updated with the pinout and connected device info: http://spreadsheets.google.com/ccc?key=0Atc5QQQNw_5ndHV3aGNua1NXdnh5N3lEQlUyS0J4V0E&hl=en )

This leaves two chips which are hard to crack, but i have some clues..

Bosch 30343 -> Judging from the surrounding hardware, it is power supply related (big capacitor, large diodes to ground, large traces).  It seems that many of Bosch's power supply ic's include other options, such as sensor inputs.  The chip appears to be PSO36 for factor (handy guide at bottom of http://www.semiconductors.bosch.de/pdf/Bosch_semiconductors_sensors_0509.pdf).  Also by the same spreadsheet, virtually all PSO36 packages are listed under 'system basis IC's and power supply ICs'.  I have checked a few of them which are NOT correct (C121, CY141, CY320), which leaves CJ910/CJ911.  The problem is that I cannot find a datasheet for them Sad 


Bosch 30380 = This one is an odd one, but the break came when finding the semiconductors and sensors summary pdf (http://www.semiconductors.bosch.de/pdf/Bosch_semiconductors_sensors_0509.pdf).  This chip has 80 pins, in an MQFP80 package.  There is only one device listed in the pdf that uses this package, the CC650 'Knock Sensor Evaluation and multichannel a/d converter' chip.  This woudl make sense, as I have traced 2 sensors back to this chip (Baro and leak detection i believe).  It also has a 'Reset Module' - and both the reset out and reset in from the CPU go to it.    Again, the problem is that I cannot find a datasheet for it Sad 


Any help finding these datasheets would be appreciated. 

Luckily we have some of the key outputs (spark, wastegate solenoid, injectors) on other chips so we should be able to start figureing with those at some point.

Camden

* the CJ920 shares a package with the CJ945c, but there is no pinout description for the CJ945c in the datasheet, and the CJ920 pin inputs/ouptuts match what is expected
Logged
Tony@NefMoto
Administrator
Hero Member
*****

Karma: +131/-4
Offline Offline

Posts: 1389


2001.5 Audi S4 Stage 3


« Reply #5 on: October 22, 2009, 11:21:51 AM »

Awesome work Camden!
Logged

Remember you have to log in if you want to see the file attachments!
Info or questions, please add to the wiki: http://www.nefariousmotorsports.com/wiki
Follow NefMoto developments on Twitter: http://twitter.com/nefmoto
robin
Full Member
***

Karma: +20/-1
Offline Offline

Posts: 139


« Reply #6 on: October 23, 2009, 04:45:34 PM »

Sweet, thank you Camden!!
Logged
af
Newbie
*

Karma: +3/-0
Offline Offline

Posts: 7


« Reply #7 on: February 24, 2010, 03:16:30 AM »

Hello guys!

Here you can download BOSH "me-motronic engine management" for understanding how-to up to date petrol engines work.
Logged
Tifon
Jr. Member
**

Karma: +3/-0
Offline Offline

Posts: 30


« Reply #8 on: March 17, 2010, 02:53:03 AM »

Hello guys!

Here you can download BOSH "me-motronic engine management" for understanding how-to up to date petrol engines work.

Af thanks for this links!!, good info.

BR.
Logged
af
Newbie
*

Karma: +3/-0
Offline Offline

Posts: 7


« Reply #9 on: March 23, 2010, 02:33:09 AM »

So I try to reverse engineering BOSH ME7.5 ECU. I prepared memory map for ME7.1 and BOSH ME7.5 that I had disassembled. You can download it here...

Maybe anyone have unused hardware ECU for prepare working schematic and PCB for free of charge.
Please write suggestions here.
Logged
af
Newbie
*

Karma: +3/-0
Offline Offline

Posts: 7


« Reply #10 on: March 23, 2010, 02:38:44 AM »

There are sensors and actuators documentation from BOSH.
Logged
ArgDub
Full Member
***

Karma: +60/-1
Offline Offline

Posts: 202


« Reply #11 on: March 24, 2010, 03:52:34 AM »

Great info, thanks for the post.
Logged
Tony@NefMoto
Administrator
Hero Member
*****

Karma: +131/-4
Offline Offline

Posts: 1389


2001.5 Audi S4 Stage 3


« Reply #12 on: March 26, 2010, 01:40:22 PM »

So I try to reverse engineering BOSH ME7.5 ECU. I prepared memory map for ME7.1 and BOSH ME7.5 that I had disassembled. You can download it here...

Maybe anyone have unused hardware ECU for prepare working schematic and PCB for free of charge.
Please write suggestions here.

Good work on the memory map. It looks correct to me. But some ME7.1 come with 1 meg flash, and not just 512kb.
Logged

Remember you have to log in if you want to see the file attachments!
Info or questions, please add to the wiki: http://www.nefariousmotorsports.com/wiki
Follow NefMoto developments on Twitter: http://twitter.com/nefmoto
af
Newbie
*

Karma: +3/-0
Offline Offline

Posts: 7


« Reply #13 on: March 27, 2010, 10:52:57 AM »

So I try to reverse engineering BOSH ME7.5 ECU. I prepared memory map for ME7.1 and BOSH ME7.5 that I had disassembled. You can download it here...

Maybe anyone have unused hardware ECU for prepare working schematic and PCB for free of charge.
Please write suggestions here.

Small changes was performed (memory map static ram physical size changed).
 
Logged
af
Newbie
*

Karma: +3/-0
Offline Offline

Posts: 7


« Reply #14 on: March 31, 2010, 12:58:59 AM »

May be someone have pdf datasheet for thees ones:



I can prepare circuit for me7.5.

Logged
Pages: [1] 2
  Print  
 
Jump to:  

Powered by SMF 1.1.21 | SMF © 2015, Simple Machines Page created in 0.026 seconds with 18 queries. (Pretty URLs adds 0.001s, 0q)